Mini Workshop Manual Saloon, Countryman, Cooper & Cooper S, Estate

Mini workshop manual - Saloon, Countryman, Traveller... scr1

Mini workshop manual – Saloon, Countryman, Traveller, Clubman, Estate, 1275GT Van, Pick-up, Moke, Cooper & Cooper S

DESCRIPTION
This Manual is intended to assist the skilled mechanic in carrying our repairs and replacements in a minimum time.
The information at the front of the book includes general data, tightening torque figures and engine tuning data. Recommended lubricants and Service tools are featured at the end of the Manual.

References to left- or right-hand side in this Manual are made when viewing the car from the rear.

MANUAL ARRANGEMENT
The Manual is divided into Sections, and each Section carries a reference letter that identifies the Section with an assembly or a major component.

Each Section is prefixed with a contents page and is sub-divided numerically. The pages and illustrations are numbered consecutively within each Section and the Section title and letter are shown at the top of each page.
Sections having the suffix ‘a’ contain supplementary information dealing with the Mini fitted with Automatic transmission.

Sections having the suffix ‘b’ contain supplementary information applicable to the Mini range, i.e. 850, 1000, Clubman, 1275 GT, and the Cooper ‘S’ Mk. III. These vehicles have NEGATIVE earth electrical systems.

CONTENTS:

  • Introduction
  • Data Contents
  • General Data
  • Tuning Data
  • Engine Ignition
  • Cooling System
  • Fuel System
  • Clutch
  • Transmission
  • Drive Shafts
  • Rear Suspension
  • Steering
  • Front Suspension
  • Hydraulic Dampers
  • Braking System
  • Electrical
  • Body
  • Service Tools
  • Recommended Lubricants

Engine Mechanical, Engine Coolant, Engine Control System, Emission Control Systems, Drive Shaft, Drive Belt, Differential Case Assy, Cylinder Head Assy, Cylinder Head, Cylinder Block Assy, Curtain Shield Air Bag Assy, Cooling System, Cooling Fan System, Combination Meter, Clutch Unit, Clutch System, Clutch Start Switch Assy, Clutch Release Cylinder Assy, Clutch Pedal Sub-Assy, Clutch Master Cylinder Assy, Cigarette Lighter Assy, Charging System, Charcoal Canister, Chain Sub-Assy, Center Stop Lamp Assy, Center Cluster Module Switch, Center Air Bag Sensor Assy, Camshaft Position Sensor, Camshaft, Brake System, Brake Pedal, Brake Master Cylinder, Brake Fluid, Brake Booster, Brake Actuator, Body Repair, Yaw Rate Sensor, Wiring Diagrams, Wire Harness Repair, Wiper Rubber, Wiper And Washer System, Wiper & Washer, Windshield Wiper Switch Assy, Windshield Wiper Motor Assy, Windshield Glass, Window Defogger System, Wheel And Tire System, Water Pump Assy, Washer Nozzle, Valve Clearance, Transmission Wire, Transmission Valve Body, Transmission Revolution Sensor, Transmission Control Cable, Torque Converter Clutch, Tire & Wheel, Throttle Body Assy, Thermostat, Supplemental Restraint System, Sun Roof System, Sun Roof, Steering System, Steering Sensor, Steering Column, Starting System, Starter Switch, Starter Assy, Spiral Cable Sub-Assy, Speed Sensor Front, Skid Control Sensor, Side Turn Signal Lamp Assy, Side Mudguard, Side Air Bag Sensor Assy, Shift Lock System, Shift & Select Lever Shaft, Sfi System, Seat Position Air Bag Sensor, Seat Belt Warning System, Seat Belt, Seat, Roof Headlining, Roof Drip Side Finish Moulding, Roof Antenna Pole Sub-Assy, Receiver Condenser Assy, Rear Wiper Rubber, Rear Wiper Motor Assy, Rear Wheel Alignment, Rear Suspension System, Rear Suspension, Rear Speaker Assy, Rear Shock Absorber Assy, Rear Seat Belt, Rear Door Window Frame Moulding, Rear Door Glass Weatherstrip, Rear Door, Rear Combination Lamp Assy, Rear Coil Spring, Rear Bumper, Rear Brake, Rear Axle Hub, Rear Axle Beam, Radio Receiver Assy, Radiator Assy, Quarter Window Assy, Pulley Compressor Assy, Preparation, Power Window Control System, Power Steering Link Assy, Power Steering, Power Source, Power Mirror Control System, Power Door Lock Control System, Passenger Air Bag Assy, Partial Engine, Parkneutral Position Switch, Parking Brake Lever, Parking Brake Cable, Parking Brake, Output Shaft Assy, Outer Rear View Mirror Assy, Oil Pump, Oil Filter, Name Plate, Manual Transaxle System, Manual Transaxle Oil, Manual Transaxle Assy, Maintenance, Lubrication System, Lighting System, License Plate Lamp Assy, Knock Sensor, Introduction, Instrument Panel, Input Shaft Assy, Inner Rear View Mirror Assy, Ignition System, Horn Button Assy, Horn, Hood, Heater Radiator Assy, Heater Or Boost Ventilator Control, Heater & Air Conditioner, Headlamp Protector Retainer, Headlamp Dimmer Switch Assy, Headlamp Assy, Generator Assy, Fuel Tank, Fuel System, Fuel Pump, Fuel Injector, Front Wheel Alignment, Front Suspension System, Front Suspension Arm, Front Suspension, Front Stabilizer Bar, Front Speaker Assy, Front Shock Absorber, Front Seat Belt, Front Seat Airbag Assy, Front Marker Lamp Assy, Front Drive Shaft, Front Door Glass Weatherstrip, Front Door, Front Differential Oil Seal, Front Bumper, Front Brake, Front Axle Hub, Floor Shift Parking Lock Cable, Floor Shift Assy, Fender Panel Mudguard, Exhaust Pipe, Exhaust, Back Door Glass, Back Door Garnish, Back Door, Automatic Transaxle Fluid, Automatic Transaxle Assy, Audio & Visual System, Antenna Cord Sub-Assy, Amplifier Antenna Assy, Air Conditioning System, Air Conditioning Blower Assy, Air Conditioning Amplifier Assy, Air Conditioner Refrigerant, Air Bag Sensor Rear, Air Bag Sensor Front…

Language: English
File: PDF
Size: 13.6 Mb
Free download Mini workshop manual – Saloon, Countryman, Traveller, Clubman, Estate, 1275GT Van, Pick-up, Moke, Cooper & Cooper S PDF
https://yadi.sk/i/COxnxtVqiMEcf